Utilizing a Pellet Tube for Smoking Meat

In case you use an electrical smoker and wish to have fixed smoke for five+ hours otherwise you use a pellet smoker and simply aren’t getting sufficient smoke taste, I’ve the answer for you!

A pellet tube crammed with pellets and lit at one finish will present fixed smoke for five+ hours relying on it’s measurement and the way full you fill it with pellets.

A few of it’s possible you’ll be right here since you’ve already tried to make use of a pellet tube and might’t hold the darn factor lit! Nicely, I’ll present you methods to repair that drawback as nicely.

• Pellet tube
• Pellets
• Torch/Lighting gadget

First, you will have a pellet tube. I exploit one which I discovered on Amazon actually low-cost and it really works nice!

Additionally, you will want pellets and nearly any pellets will work. I typically use the Pit Boss model from Wally world as a result of they’re low-cost and so they work nicely within the smoke tube in addition to in my pellet people who smoke.

You can too buy pellets on amazon however they are going to value greater than what yow will discover regionally. Your alternative there!

Third and probably most necessary, you will have a propane or butane torch. I just like the bigger Bernzomatic torches like plumbers use however the smaller creme brûlée torches may even work simply fantastic.

Right here’s the torch I exploit which yow will discover at Wally World, HD or nearly some other retailer that sells {hardware} and instruments.

Fill the tube all the way in which full with dry pellets.

Notice: I’ve been recognized to microwave my pellets in a bowl for a minute or two earlier than inserting them within the tube to ensure they’re dry however that is simply one thing I do to ensure, it’s in all probability not typically needed.

I have a tendency to put the smoke tube horizontally on a flat, fire-proof floor however I’ve seen some stand them straight up through the lighting process.

Which smoke tube place do you assume is best? Put up it within the remark part beneath.

Activate the torch and maintain the flame to the pellets for about 45 seconds to get them to burning actual good.

As soon as they’re burning, permit them to burn for round 7 minutes to create a very nice mattress of coals. This mattress of coals is among the key elements that retains the pellets going for 4 to five hours unattended.

If the pellets are nonetheless burning after 7 minutes, blow out the flame and proceed on to the following step.

Each smoker is completely different and placement is one thing that varies from smoker to smoker. The 2nd key part to creating positive the smoke tube retains smoking for hours on finish is air.

The smoke tube should get a provide of air through a vent, gap, opening, and so on. in order that it could possibly proceed burning.

As an illustration, I usually use a smoke tube within the Reqtec pellet smoker. I place it straight on the grate all the way in which to the left, proper subsequent to the probe entry gap and that offers it loads of air.

Within the Masterbuilt electrical people who smoke, the smoke tube will set on the underside rack proper subsequent to the woodchip chute. The chute must be open to permit air to enter and hold the smoke tube going.

In case you don’t have a vent or opening, you possibly can modify your smoker or grill to create an air inlet so long as this gained’t void your present guarantee.

In case you use a smoke tube in your smoker, let me know within the remark space beneath what place works for you in your smoker. Remember to tell us what sort, mannequin, era, and so on. of smoker you’ve gotten.

Notice: I like to recommend NOT utilizing the water pan when utilizing a smoke tube. The additional moisture within the smoker might mess with the smoke tube staying lit and this isn’t good. If doable, go away the water pan dry when utilizing a smoke tube.

1. Be certain the pellets are dry. In case you suspect the pellets are in the slightest degree damp, pour them right into a bowl and microwave them for a minute or two to assist dry them.
2. Maintain the lighter/torch to the pellets for 45 seconds. This enables extra pellets to begin burning which provides you with a greater mattress of coals to maintain the pellets burning contained in the smoker.
3. Let the pellets burn uninterrupted for a minimum of 7 minutes to create that mattress of coals we talked about in #2 above.
4. Be certain the pellet tube is getting adequate air. The pellets should get a gentle provide of oxygen to proceed burning for hours on finish. If the pellets are going out, they could be starved for air.

For much more smoke taste, you should utilize wooden chips in with the pellets.

I like to recommend NOT utilizing wooden chips solely however layering them. As an illustration, a layer of pellets, then a layer of wooden chips, adopted by one other layer of pellets and so forth and so forth.

Pellets are likely to burn extra cleanly than wooden chips and whereas it is a wonderful thing about pellets, it additionally means the flavour could be much less robust than wooden chips.

I like to recommend inserting pellets as your final layer and that’s the layer that you just mild to create an excellent mattress of coals.

Give it a attempt to see what you assume.

If in case you have different ideas for lighting the pellet tube and/or protecting it lit for hours on finish, tell us within the comments area beneath.

Notice: You can too order the formulation for my rubs and sauce and make these your self at residence. Seize these HERE and obtain instantly.